Keystone is recalling 11 MY 2008 Outback loft travel trailers model 27V. The loft roof lift mechanism may not be properly secured. If the loft roof lift mechanism is not properly secure and/or used without the safety poles, an increased risk or personal injury and property damage exists. Dealers will secure the lift mechanism with different fasteners. The remedy will be performed free of charge. The recall began on June 5, 2009. Owners may contact Keystone customer service at 1-866-425-4369.
Prevost is recalling 47 MY 2009 X3-45 and MY 2010 H3-41, and H3-45 coaches equipped with Dana Ibeam axle front suspension. The dimension of the steering drag link tie rod end does not meet the manufacturer”s requirements. The tie rod end could break and create loss of steering control, increasing the risk of a crash. Dealers will inspect the drag link tie rod end and replace the part free of charge. The recall began on June 30, 2009. Owners may contact Prevost at 1-418-883-2888.
Fleetwood is recalling 62 MY 2009-2010 Tioga Ranger and Jamboree Sport Class C motor homes built on Ford E450 chassis that have had the wheelbases extended, have also required an extended brake line. The brake line extension has been identified as a potential source for brake fluid leaks. Loss of brake fluid may result in longer stopping distances and/or loss of brakes. Loss of brakes may result in a vehicle crash. Dealers will inspect and replace the brake line extension and/or connection fittings free of charge. The manufacturer has not yet provided an owner notification schedule. Owners may contact Fleetwood at 1-800-509-3418.
Keystone is recalling 44 MY 2009 Fuzion fifth wheel trailers for failing to comply with the requirements of Part 567, “Certification.” The Federal identification label and tire loading information label does not contain the correct tire inflation pressure. Improper tire pressure can lead to tire failure and an increased risk of property damage. Dealers will mail the appropriate labels free of charge. If the customer requires assistance installing the labels, a dealer will install the label. The recall began on June 12, 2009. Owners may contact Keystone RV at 1-866-425-4369.
Coachmen is recalling 2,555 MY 2000-2009 Georgie Boy and Coachmen recreational trailers equipped with axles that include BOSCH ZOPS or ZOHT pin slide hydraulic disc brakes. When combined with occasional or seasonal vehicle operation may experience calipers sticking in the applied position. This can result in abnormal heat generation at the wheel end causing brake drag. The driver would normally have warning of the brake drag if undetected by the driver. The driver would normally detect the brake drag but if undetected the temperature increase at the wheel end can eventually lead to soft pedal conditions due to brake fluid boil, and possible extended stopping distance increasing the risk of a crash. Dealers will inspect and replace the necessary components free of charge. Workhorse is handling the remedy for this campaign. The manufacturer has not yet provided an owner notification schedule. Owners may contact Workhorse at 1-877- 246-7731 or Coachmen at 1-574-266-4030, option 5.
Fleetwood is recalling 509 MY 2001-2008 Class A motor homes equipped with axles that include BOSCH ZOPS or ZOHT pin slide hydraulic disc brakes. When combined with occasional or seasonal vehicle operation may experience calipers sticking in the applied position. This can result in abnormal heat generation at the wheel end causing brake drag. The driver would normally have warning of the brake drag if undetected by the driver. The driver would normally detect the brake drag but if undetected the temperature increase at the wheel end can eventually lead to soft pedal conditions due to brake fluid boil, and possible extended stopping distance increasing the risk of a crash. Dealers will inspect and replace the necessary components free of charge. Workhorse is handling the remedy for this campaign. The manufacturer has not yet provided an owner notification schedule. Owners may contact Workhorse at 1-877-246-7731. Workhorse will conduct te owner and dealer notification.
MCI is recalling 29 Model Year 2009 D4505 motor coaches manufactured between February and April 2009, equipped with Koni shock absorbers. When the coach is moving in rear-rise mode, the tag suspension air springs can generate force that exceeds the maximum allowable tensile strength of the shock absorbers exceeding their design rebound limit. This failure could result in separation of the shock absorber from its mounting, causing interference between the upper portion of the suspension and the driveshaft, possibly resulting in a vehicle crash. MCI will notify owners and will repair the coaches free of charge. The safety recall is expected to begin during July 2009. Owners may contact MCI at 1-847-285-2000.
Diamond Coach is recalling 10 model year 2008 and 2009 VIP motor coaches manufactured between November 25, 2008 and March 23, 2009, equipped with Carrier K410 rooftop mounted condensers. The cover of the condenser assembly may interfere with the coil header when the cover is placed on the unit assembly. The potential interference prevents the cover from resting on the unit mounting surface, creating a gap between the cover and unit assembly. This condition will not permit the cover fasteners to securely clamp the cover to the unit assembly, which may result in the cover dislocating from the unit during operation, possibly causing a crash or cause injury to pedestrians. Diamond Coach will repair the coaches free of charge. The safety recall began on June 11, 2009. Owners may contact Diamond Coach toll-free at 1-800-673-2431 ext. 21.
Four Winds is recalling 684 MY 2002-2006 Infinity, MY 2002-2007 Windesport, MY 2004-2008 Hurricane, MY 2006-2007 Megallan and MY 2008 Fun Mover motor homes equipped with axles that include BOSCH ZOPS or ZOHT pin slide hydraulic disc brakes. When combined with occasional or seasonal vehicle operation may experience calipers sticking in the applied position. This can result in abnormal heat generation at the wheel end causing brake drag. The driver would normally have warning of the brake drag if undetected by the driver. The driver would normally detect the brake drag but if undetected the temperature increase at the wheel end can eventually lead to soft pedal conditions due to brake fluid boil, and possible extended stopping distance increasing the risk of a crash. Dealers will inspect and replace the necessary components free of charge. Workhorse is handling the remedy for this campaign. Workhorse will conduct the owner and dealer notification. Owners may contact Workhorse at 1-877-246-7731.
Airstream is recalling 6 MY 2003-2006 35XL, and 355XL motor homes equipped with axles that include BOSCH ZOPS or ZOHT pin slide hydraulic disc brakes. When combined with occasional or seasonal vehicle operation may experience calipers sticking in the applied position. This can result in abnormal heat generation at the wheel end causing brake drag. The driver would normally have warning of the brake drag if undetected by the driver. The driver would normally detect the brake drag but if undetected the temperature increase at the wheel end can eventually lead to soft pedal conditions due to brake fluid boil, and possible extended stopping distance increasing the risk of a crash. Dealers will inspect and replace the necessary components free of charge. Workhorse is handling the remedy and owner notification for this campaign. Owners may contact Workhorse at 1-877-246-7731.
Newmar is recalling 2,578 motorhomes equipped with axles that include BOSCH ZOPS or ZOHT pin slide hydraulic disc brakes. When combined with occasional or seasonal vehicle operation may experience calipers sticking in the applied position. This can result in abnormal heat generation at the wheel end causing brake drag. The driver would normally have warning of the brake drag if undetected by the driver. The driver would normally detect the brake drag but if undetected the temperature increase at the wheel end can eventually lead to soft pedal conditions due to brake fluid boil, and possible extended stopping distance increasing the risk of a crash. Dealers will inspect and replace the necessary components free of charge. Workhorse is handling the remedy and owner notification for this campaign. Owners may contact Workhorse at 1- 877-246-7731.
Jayco is recalling 647 MY 2009 Jay Feather EXP and EX-Port travel trailers. The screws used to attach the bunk door cables to the bunk doors may be of insufficient length, which could result in the cable becoming detached from the door while the travel trailer is parked and set up with the bunk doors open. If this condition is not addressed, it could possibly result in an injury. There is no potential for this situation to occur while the vehicle is being towed. Dealers will replace the screws attaching the cables to the bunk door with longer fasteners. The recall is expected to begin during July 2009. Owners may contact Jayco at 1-800-283-8267.
Starcraft is recalling 108 MY 2009 Travel Star EXP trailers. The screws used to attach the bunk door cables to the bunk doors may be of insufficient length, which could result in the cable becoming detached from the door while the travel trailer is parked and set up with the bunk doors open. If this condition is not addressed, it could possibly result in an injury. There is no potential for this situation to occur while the vehicle is being towed. Dealers will replace the screws attaching the cables to the bunk door with longer fasteners. The recall is expected to begin during July 2009. Owners may contact Starcraft at 1-800-945-4787.
Damon is recalling 2,415 motorhomes equipped with axles that include BOSCH ZOPS or ZOHT pin slide hydraulic disc brakes. When combined with occasional or seasonal vehicle operation may experience calipers sticking in the applied position. This can result in abnormal heat generation at the wheel end causing brake drag. The driver would normally detect the brake drag but if undetected the temperature increase at the wheel end can eventually lead to soft pedal conditions due to brake fluid boil, and possible extended stopping distance increasing the risk of a crash. Dealers will inspect and replace the necessary components free of charge. Workhorse is handling the remedy and owner notification for this campaign. Owners may contact Workhorse at 1-877-246-7731.
Keystone is recalling 52 MY 2010 Passport travel trailers for failing to comply with the requirements of part 567, “Certification.” These vehicles were manufactured with incorrect axle(s). The axle rating may not match the specifications listed on the federal certification label and the tire and loading label. Towing a vehicle with the axle loaded beyond the specified weight rating may result in axle failure leading to poor vehicle handling and an increased risk of a crash. Dealers will inspect the axle rating tags, compare to the federal certification label and then if they do not match either replace the axle if under rated or replace the labels if over rated. The remedy will be performed free of charge. The recall began on June 22, 2009. Owners may contact Keystone Customer Service at 1-866-425-4369.
Dutchmen is recalling 2,735 MY 2005-2010 N’Tense, Victory Lane, Winner’s Circle, Wild Thing, Four Winds, and Dutchmen recreational trailers. These trailers contain a fuel dispensing system with a shut-off switch which is not spark protected and is mounted in the nozzle storage compartment of the fuel dispensing system. Gasoline spilled on the switch, or gasoline vapors which might build up in the vicinity of the switch during dispensing functions, may create a fire or explosion if a spark is generated by the switch. The resulting fire or explosion could result in serious burns and possibly death. Dealers will provide an ignition protected switch and insulated terminals to replace the current switch. The remedy will be performed free of charge. The recall is expected to begin on or before July 9, 2009. Owners may contact Dutchmen at 1-866-869-1109.
Fleetwood is recalling 683 MY 2005-2006 Bounder 35E class a motor homes when the refrigerator is operated in the LPG mode, the refrigerator exhaust may vent into the interior of the refrigerator cabinet rather than exhaust to the exterior through a vent for that purpose. The hot exhaust may result in heat damage to the interior of the refrigerator cabinet and could result in a fire. Dealers will inspect the refrigerator cabinet and install a baffle in the rear of the refrigerator cabinet to divert the hot exhaust to the exterior vent. The remedy will performed free charge. The manufacturer has not yet provided an owner notification schedule. Owners may contact Fleetwood Motor Homes at 1-800-509-3418.
Gulf Stream is recalling 15 motor homes equipped with axles that include Bosch ZOPS or ZOHT pin slide hydraulic disc brakes. When combined with occasional or seasonal vehicle operation may experience calipers sticking in the applied position. This can result in abnormal heat generation at the wheel end causing brake drag. The driver would normally detect the brake drag but if undetected the temperature increase at the wheel end can eventually lead to soft pedal conditions due to brake fluid boil, and possible extended stopping distance increasing the risk of a crash. Dealers will inspect and replace the necessary components free of charge. Workhorse is handling the remedy and owner notification for this campaign. Owners may contact Workhorse at 1-877-246-7731.
Triple E is recalling 16 motor homes equipped with axles that include BOSCH ZOPS or ZOHT pin slide hydraulic disc brakes. When combined with occasional or seasonal vehicle operation may experience calipers sticking in the applied position. This can result in abnormal heat generation at the wheel end causing brake drag. The driver would normally detect the brake drag but if undetected the temperature increase at the wheel end can eventually lead to soft pedal conditions due to brake fluid boil, and possible extended stopping distance increasing the risk of a crash. Dealers will inspect and replace the necessary components free of charge. Workhorse is handling the remedy and owner notification for this campaign. Owners may contact Workhorse at 1-877-246-7731.
Newmar is recalling 328 Model Year 2008 through 2010 recreational vehicles manufactured between April 16, 2007 and April 22, 2009. An inadvertent deviation in ground cable sizing occurred resulting in wire gauge undersizing. Undersized electrical conductors may result in conductor failure, creating a shock or fire hazard without warning. Newmar will notify owners and provide a free remedy. The safety recall is expected to begin during August 2009. Owners may contact Newmar at 1-574-773-7791.
Universal Specialty is recalling 12 MY 2002-2006 Eagle class a motor homes equipped with axles that include BOSCH ZOPS or ZOHT pin slide hydraulic disc brakes. The calipers on these brakes may stick when the brakes are applied, which can result in abnormal heat generation at the wheel end causing brake drag. If the brake drag is left undetected, the temperature increase at the wheel end can eventually lead to soft pedal conditions and extended stopping distances, thereby increasing the risk of a crash. Dealers will inspect and replace the necessary components free of charge. Workhorse is handling the remedy and owner notification for this campaign. Owners may contact Workhorse at 1-877-246-7731.
Roadtrek is recalling 23 MY 2009 Class B motor homes built on Chevrolet 2500 van chassis. The propane distribution systems installed on these vehicles may contain a defective brass tee fitting that has too short of a thread such that, when connected to another fitting, the connection between the two fittings is not completely sealed. An unsealed connection could result in a propane leak, resulting in a possible fire hazard. Dealers will inspect and replace the defective brass tee connector fitting free of charge. The recall began on July 17, 2009. Owners may contact Roadtrek at 1-888-762-3873.
Showtime Conversions is recalling 3 MY 2001 and 2002 Showhauler motorhomes equipped with Norcold model 1200LRIM refrigerators, manufactured from March 1, 2001 to December 31, 2002, with serial numbers between 1273701 and 1536607, non-consecutively. A fatigue failure in the section of the cooling unit which contains the refrigerant could allow the liquid solution to slowly leak. If a leak occurs and the refrigerator continues to be operated after solution circulation has ceased the heat source could generate very high temperatures. At such high temperatures, the cooling unit could rupture. If a leak occurs and the unit is continues to operate, hydrogen gas may be expelled and can be ignited, resulting in a fire, possibly causing serious injury or death. Showtime will notify owners and the vehicle’s refrigerator will be repaired free of charge. The safety recall began on August 3, 2009. Owners may contact Showtime Conversions at 1-574-825-1130 or Norcold’s Recall Center at 1-800-767-9101.
Jayco is recalling 273 model year 2002-2004 Legacy fifth wheel motor homes equipped with Norcold model 1200LRIM refrigerators, manufactured from March 1, 2001 to December 31, 2002, with serial numbers between 1273701 and 1536607, non-consecutively. A fatigue failure in the section of the cooling unit which contains the refrigerant could allow the liquid solution to slowly leak. If a leak occurs and the refrigerator continues to be operated after solution circulation has ceased the heat source could generate very high temperatures. At such high temperatures, the cooling unit could rupture. If a leak occurs and the unit is continues to operate, hydrogen gas may be expelled and can be ignited, resulting in a fire, possibly causing serious injury or death. Jayco will notify owners and the vehicle’s refrigerator will be repaired free of charge. The safety recall is expected to begin during August 2009. Owners may contact Jayco at 1-800-283-8267 or Norcold’s recall center at 1-800-767-9101.
Coachmen is recalling 932 Model Year (MY) 1999-2003 Georgie Boy Cruise Master, MY 2000-2002 Maverick and Pursuit, MY 2000 & 2002 Cruise Air and MY 2001-2002 Suite motorhomes equipped with Norcold model 1200LRIM refrigerators, manufactured from March 1, 2001 to December 31, 2002, with serial numbers between 1273701 and 1536607, non-consecutively. A fatigue failure in the section of the cooling unit which contains the refrigerant could allow the liquid solution to slowly leak. If a leak occurs and the refrigerator continues to be operated after solution circulation has ceased the heat source could generate very high temperatures. At such high temperatures, the cooling unit could rupture. If a leak occurs and the unit is continues to operate, hydrogen gas may be expelled and can be ignited, resulting in a fire, possibly causing serious injury or death. Coachmen is working with Norcold and Norcold will notify owners and the vehicle’s refrigerator will be repaired free of charge. Owners may contact Norcold’s recall center at 1-800-767-9101.
Foretravel is recalling 1 Model Year 2002 U320 recreational vehicle equipped with a Norcold Model 1200LRIM refrigerator, manufactured from March 1, 2001 to December 31, 2002, with serial number between 1273701 and 1536607, non-consecutively. A fatigue failure in the section of the cooling unit which contains the refrigerant could allow the liquid solution to slowly leak. If a leak occurs and the refrigerator continues to be operated after solution circulation has ceased the heat source could generate very high temperatures. At such high temperatures, the cooling unit could rupture. If a leak occurs and the unit is continues to operate, hydrogen gas may be expelled and can be ignited, resulting in a fire, possibly causing serious injury or death. Foretravel is working with Norcold and Norcold will notify owners and the vehicle’s refrigerator will be repaired free of charge. Owners may contact Norcold’s Recall Center at 1-800-767-9101.
Winnebago is recalling 1,547 Model Year 2001-2003 recreational vehicles equipped with Norcold model 1200LRIM refrigerators, manufactured from March 1, 2001 to December 31, 2002, with serial numbers between 1273701 and 1536607, non-consecutively. A fatigue failure in the section of the cooling unit which contains the refrigerant could allow the liquid solution to slowly leak. If a leak occurs and the refrigerator continues to be operated after solution circulation has ceased the heat source could generate very high temperatures. At such high temperatures, the cooling unit could rupture. If a leak occurs and the unit is continues to operate, hydrogen gas may be expelled and can be ignited, resulting in a fire, possibly causing serious injury or death. Winnebago is working with Norcold and Norcold will notify owners and the vehicle’s refrigerator will be repaired free of charge. Owners may contact Norcold’s recall center at 1-800-767- 9101.
Keystone RV is recalling certain Model Year 2010 recreational vehicles manufactured from May 12 through June 19, 2009. The glass may not be properly adhered to the door in certain MiChef brand model EM925RZT microwave ovens. Only those vehicles with the following MiChef microwave serial number ranges (last 6 digits) are included in the recall: 000050-100, 000225-250, 000300-325, 000425-450, and 000460-500. The microwave is installed in an overhead cabinet. The glass could fall out and injure a nearby person. Keystone RV will notify owners and replace the microwave free of charge. The safety recall is expected to begin during August 2009. Owners may contact Keystone Customer Service at 1-866-425-4369.
Fleetwood RV is recalling certain Model Year 2005 and 2006 motorhomes manufactured between July 24, 2004 and March 11, 2005, equipped with Norcold model 1200LR, 1200LRIM, and 1201LRIM refrigerators with serial numbers between 1273701 and 1536607, non-consecutively. A fatigue failure in the section of the cooling unit which contains the refrigerant could allow the liquid solution to slowly leak. If a leak occurs and the refrigerator continues to be operated after solution circulation has ceased the heat source could generate very high temperatures. At such high temperatures, the cooling unit could rupture. If a leak occurs and the unit is continues to operate, hydrogen gas may be expelled and can be ignited, resulting in a fire, possibly causing serious injury or death. Fleetwood RV will notify owners and the vehicle’s refrigerator will be repaired free of charge. The safety recall is expected to begin during August 2009. Owners may contact Fleetwood RV at 1- 800-509-3418 or Norcold’s Recall Center at 1-800-767-9101.
Newmar is recalling certain model year 2003 and 2004 motor homes and recreational vehicle trailers manufactured between March 5, 2002 and April 3, 2003, equipped with certain Norcold refrigerators. The coolant solution in these cooling units can escape. If a leak occurs and the unit continues to operate, hydrogen gas may be expelled and can be ignited, resulting in a fire, possibly causing serious injury or death. Newmar is working with Norcold to notify owners and the vehicles will be repaired free of charge. The remedy campaign will be conducted by Norcold. The safety recall campaign is expected to begin during September 2009. Owners may contact Norcold Service Center at 1-800-767-9101 or Newmar at 1-574-773-7791.
Dutchmen is recalling certain model year 2009-2010 Dutchman and Four Winds trailers manufactured by Dutchman because they fail to comply with the requirements of part 567, “Certification.” The federal identification tag tire and loading information label does not contain the correct size. During replacement of the tires, a consumer could install the incorrect tire potentially leading to a crash. Dutchman will mail the appropriate labels to owners free of charge. If the customer requires assistance installing the labels, a dealer will install the label. The recall is expected to begin on or before September 4, 2009. Owners may contact Dutchmen at 1- 866-869-1109.
Be the first to know about future RV recalls at Twitter.
Posted under Uncategorized
This post was written by Chuck on October 2, 2009
